Toyota Yaris: Service specifications - Specifications - Toyota Yaris XP90 2005–2010 Owner's ManualToyota Yaris: Service specifications


Valve clearance (engine cold), mm (in.): Intake 0.15—0.25 (0.006—0.010).

Exhaust 0.25—0.35 (0.010—0.014).

Spark plug type: DENSO SK16R11.


Spark plug gap, mm(in.):
1.1 (0.043).

Drive belt tension measured with Boroughs drive belt tension gauge No. BT-33-73F (used belt), lbf: Generator belt 100 20.


Oil capacity (drain and refill), L (qt., Imp. qt.): With filter 3.7 (3.9, 3.3).

Without filter 3.4 (3.6, 3.0).

“Toyota Genuine Motor Oil” is used in your Toyota vehicle. Use Toyota approved “Toyota Genuine Motor Oil” or equivalent to satisfy the following grade and viscosity.

Oil grade: ILSAC multigrade engine oil.

Please contact your Toyota dealer for further details.

Recommended oil viscosity: SAE 5W-30.



Total capacity, L (qt., Imp. qt.): Manual transmission 4.8 (5.1, 4.2).

Automatic transmission 4.7 (5.0, 4.1).

Coolant type: “Toyota Super Long Life Coolant” is used in your Toyota vehicle at factory fill. In order to avoid technical problems, only use “Toyota Super Long Life Coolant” or similar high quality ethylene glycol based non-silicate, non-amine, non- nitrite, and non-borate coolant with long-life hybrid organic acid technology.

(Coolant with long-life hybrid organic acid technology is a combination of low phosphates and organic acids.).

Do not use plain water alone.

Please contact your Toyota dealer for further details.


Open voltage* at 20 C (68 F):
12.6—12.8 V Fully charged.

12.2—12.4 V Half charged.

11.8—12.0 V Discharged.

*: Voltage that is checked 20 minutes after the key is removed with all the lights turned off.

Charging rates: 5 A max.


Pedal free play, mm (in.): 5—15 (0.2—0.6)

Fluid type: SAE J1703 or FMVSS No. 116 DOT 3


Oil capacity, L (qt., Imp. qt.):
1.9 (2.0, 1.7)

Oil type: Gear oil API GL-4 or GL-5

Recommended oil viscosity: SAE 75W-90


Fluid capacity (drain and refill), L (qt., Imp. qt.): 2.5 (2.6, 2.2)

Fluid type: Toyota Genuine ATF Type WS

Change automatic transmission fluid only as necessary.

Generally, it is necessary to change automatic transmission fluid only if your vehicle is driven under one of the Special Operating Conditions listed in your “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”. When changing the automatic transmission fluid, use only “Toyota Genuine ATF Type WS” (ATF JWS3324 or NWS9638) to aid in assuring maximum transaxle performance.

Notice: Using automatic transmission fluid other than “Toyota Genuine ATF Type WS” may cause deterioration in shift quality, locking up of your transmission accompanied by vibration, and ultimately damage the automatic transmission of your vehicle.

Please contact your Toyota dealer for further details.


Minimum pedal clearance when depressed with the pressure of 300 N (30 kgf, 66 lbf) with the engine running, mm (in.): With anti-lock brake system 73 (2.9).

Without anti-lock brake system 70 (2.8).

Pedal free play, mm (in.): 1—6 (0.04—0.24)

Pad wear limit, mm (in.):
1.0 (0.04)

Lining wear limit, mm (in.):
1.0 (0.04)

Parking brake adjustment when pulled with the force of 200 N (20 kgf, 45 lbf): 6—9 clicks

Fluid type: SAE J1703 or FMVSS No. 116 DOT 3


Wheel free play: Less than 30 mm (1.2 in.)

    Fuel type: Unleaded gasoline, Octane Rating 87 (Research Octane Number 91) or higher Fuel tank capacity, L (gal., Imp. gal.): 42 (11.1, 9.2) ...

    Tire size and cold tire inflation pressure: Front and rear kPa (kgf/cm2 or bar, psi) Tire size Front Rear Wheel size P175/65R14 81S 220 (2.2, 32) 22 ...

    See also:

    Trailer towing (except 3-door models for Canada)
    Toyota does not recommend towing a trailer with your vehicle. Toyota also does not recommend the installation of a tow hitch or the use of a tow hitch carrier for a wheelchair, scooter, bicycle, e ...

    Front body pillar (CUT): Hatchback
    REPLACEMENT With the cowl top side upper panel removed. REMOVAL INSTALLATION Temporarily install the new parts and measure each part of the new parts in accordance with the body dimension ...

    Odometer and two trip meters
    With tachometer Without tachometer This meter displays the odometer and two trip meters. 1. Odometer—Shows the total distance the vehicle has been driven. 2. Two trip meters—Shows tw ...